Hi-Lo camper travel trailer forum

Hi-Lo camper travel trailer forum (https://www.hilotrailerforum.com/)
-   General Hi-Lo camper discussion (https://www.hilotrailerforum.com/f17/)
-   -   Floor (https://www.hilotrailerforum.com/f17/floor-1167/)

rhbauer78 06-08-2011 05:35 AM

Floor
 
Thea section of the floor in the bathroom of my 86 HI LO has rotten out. Any tips on how to replace it without removing the sewer tank??

RichR 06-08-2011 06:13 AM

Welcome to the forum. You happen to be in luck, floor replacement was just discussed here a few days ago. Look here:https://www.hilotrailerforum.com/f27/...oor-soft-1035/

There have been many topics discussed over the past, just go to search and enter a word or phrase and you may get lots of information. If you don't find it, there are lots of members that are willing to give you help.

Rich

rhbauer78 06-09-2011 10:43 AM

Floor information
 
Thanks for the info on replacing the floor in the bathroom. One more guestion
Is there anyway to remove the toilet flange from the wast tank. To put a new floor down I think it needs to me removed. Also where are the metal floor joist located on a 86 fun chaser Any info will be a help

Richard

JMDoering 06-09-2011 05:07 PM

Richard,

On both of our Hi-Lo's, the flange is threaded to the waste tank, and is pretty easy to remove.

Regarding the "metal floor joists," AKA frame members, unless I'm completely misunderstanding your question, you should be able to locate by climbing under the trailer and looking.

Jim

rhbauer78 06-10-2011 02:34 PM

Thanks to everyone for all the information, A great help for this old boy (80)
Am leaving Sunday for Acadia National Park. It is one of my Hi Lo's favorite places. Richard

RichR 06-10-2011 08:00 PM

Our Hi-Lo likes it there also. Have a great time. Be sure to hit the Trenton Bridge Lobster Pound. :)

robobd 06-11-2011 08:46 AM

hi rhbauer78
 
Hi, i am robobd, and i just replaced my floor on my 88 22L to see where your floor joists are, crawl under the trailer from the back or side. let me start over, first determine what parts of your floor is bad. I used a larger flat end punch, and used my hand to push down on the whole floor to determine all the soft spots, then I used a magic marker to out line the soft areas. I then measured from the back wall to the edge of the soft spots I marked, then I added two more inches to it. I then measured from my street side wall (which was bad on my hi-lo) to the edge of the soft line , then I crawled under and measured under the trailer to see how far over was the floor joists, went back inside and transfered over the lines where the joists were. remember there is an inch difference (wider) from your inside measurement. to make sure, measure 3 times, and cut one time. I also went under and drilled up right next to the joist on my short side to determine how far over to cut, then measured from the inside, added a 1/2" to determine where the center of the stud is. marked where the cut needed to be , I used an osolating cutting tool from harbor freight (39.00) and cut a 1/4" depth at a time so I would not cut my black water tank. please read my other post on soft floor.
If you have any questions, pleas ask no matter how small it may seem, an unkown answer could be the difference between $!.00 or a $1000.00 if not knowing how to do it!

rhbauer78 06-26-2011 12:36 PM

floor reply
 
Just want to say a great big thanks for all the help I received. Sure makes life easier. Richard

sam 06-27-2011 12:48 AM

Replacing vinyl flooring
 
Today our HiLo goes in to the floor place to have a professional install,new vinyl. Here is what the installer told us/is going to do. Old vinyl will be left in place.Entire floor will be skimcoated and new vinyl will be glued down. Not enough clearance to use subfloor. Only used sub floor to make a patch around toilet/rotted floor,hubby did this part of the repair. This is my christmas present to my self. Must have been good!!!! sam


All times are GMT -5. The time now is 08:11 AM.

Powered by vBulletin® Version 3.8.8 Beta 4
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
HiLoTrailerForum.com Copyright 2010