Hi-Lo camper travel trailer forum

Hi-Lo camper travel trailer forum (https://www.hilotrailerforum.com/)
-   General Hi-Lo camper discussion (https://www.hilotrailerforum.com/f17/)
-   -   Front maker lights not working (https://www.hilotrailerforum.com/f17/front-maker-lights-not-working-2369/)

traverlaw 08-19-2012 07:18 PM

Front maker lights not working
 
I have a 2003 HiLo TrailLite 24-foot and the front marker lights are not getting power. How is this wiring routed? Where is the likely break in the wiring?

RCREYES 08-19-2012 11:47 PM

Quote:

Originally Posted by traverlaw (Post 14723)
I have a 2003 HiLo TrailLite 24-foot and the front marker lights are not getting power. How is this wiring routed? Where is the likely break in the wiring?

Welcome to the forum! Here's the link to the electrical section in the reference library. Hope it helps.

Electrical - Hi-Lo camper travel trailer forum

jcurtis95 08-20-2012 07:13 AM

Quote:

Originally Posted by traverlaw (Post 14723)
I have a 2003 HiLo TrailLite 24-foot and the front marker lights are not getting power. How is this wiring routed? Where is the likely break in the wiring?

You might 'carefully' remove the mounting screws for the running lights and check the wiring behind them. Using a volt-ohm meter, check for voltage as well as ground continuity. Sometimes, the metal becomes corroded and you can use sand paper or knife blade to scratch the corrosion off so good contact is made with the bulb. You may have to add some tension to the contact so ensure it has good contact with the bulb. I emphasize using care in removing these fixtures as they are not constructed very well and they will break. I had to use gorilla glue to glue the mount back together as it broke apart when I removed it.

If I'm not mistaken, there is one continuous run for the battery and ground for the running lights. If some are working and others are not, the wiring is attached to the mount with two in and out tension connectors and one conductor may have pulled loose allowing one bulb to burn while succeeding lights will not.

Hope this helps.

Jerry Curtis
2406 T

sam 08-20-2012 09:50 AM

Front marker lights
 
DH had to take our back lighs apart and do quite a bit of soldering. This would also be a good time to check the caulk around the lights as this can be an area of water intrusion. He used some type of electrical grease. The wires or other parts can be purchased at Napa Auto store. It would also be a good time to check all outside lights,grease and check the caulk.

traverlaw 08-21-2012 05:25 PM

Thanks! Did that, replaced the ligths with LEDs, no luck. Checked the bare line with a Volt meter and the line was dead, but the back lights work. It seems that someplace between the back lights and the front, a wire was broken.

How is that wire routed? Anybody know?

sam 08-21-2012 07:59 PM

Front lights not working
 
Give my HiLo parts person a call. Jay Simon at Mantelli trailer sales. !-716-625-8877. Didn't want to leave you with out any kind of help.


All times are GMT -5. The time now is 03:50 AM.

Powered by vBulletin® Version 3.8.8 Beta 4
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
HiLoTrailerForum.com Copyright 2010