Journey with Confidence RV GPS App RV Trip Planner RV LIFE Campground Reviews RV Maintenance Take a Speed Test Free 7 Day Trial ×
 
 


General Hi-Lo camper discussion The perfect place to discuss your Hi-Lo camper
Reply
 
Thread Tools Search this Thread Display Modes
 
Old 04-22-2017, 10:39 AM   #1
Junior Member
 
Join Date: Feb 2017
Location: ohio
Posts: 2
Default Stuck in campground

After parking at campground in my 1985 hi-lo voyager and raising it I noticed the hydraulic cylinder blew out in the up position. It is on the safety so I need to lift it to lower but can't.

Is there a manual way to lift top to release safety so that I can get top down.
__________________

jackarussel is offline   Reply With Quote
Old 04-22-2017, 11:20 AM   #2
Site Team
 
Treeclimber's Avatar
 
Join Date: Feb 2015
Location: SWFL Bonita Springs/Andrews, NC
Posts: 1,264
Default

You can't do this without help. I've seen this only once before. It requires 2 X4s, at least two farm jacks and patients. With the jacks placed in the front corners and 2bys in rear (cut to fit). Jack the front a couple of inches. Place two more 2bys wedged in front. Move jacks to rear. Repeat. Using a suitable block of wood,, wedge it in to release the safety bar. ENSURE THERE IS NO PRESSURE ON THE BAR, IT MUST BE FREE AT THIS TIME! Lower the rear till it almost binds, safely wedge cut 2bys there and repeat in front to rear as needed to the lowered position. At all times please be aware of where everyone is. Without a crane or fork lift, this is the safe way to do it that I know of. Please, let us know how you make out as it happen to another. HOPE NOT.
Tree
__________________

__________________
Treeclimber
2703 Tow Lite
2002 Escalade
Bonita Springs, Fl. &
Andrews, NC
Treeclimber is offline   Reply With Quote
Old 04-22-2017, 11:29 AM   #3
Site Team
 
JackandJanet's Avatar
 
Join Date: Jul 2010
Location: Pine, AZ
Posts: 4,525
Default

If you could find four strong men, they could probably lift the top at the corners far enough for you to release the safety bar.

- Jack
__________________
Hi-Lo 1707T - Tire Minder TPMS on Tow Vehicle and Trailer, 300W Solar Battery Charger, Equal-i-zer WDH, Progressive Dynamics Converter, Fan-Tastic Fan, LiFePO4 battery 12V DC Electrical System
2014 F150 Platinum 4x4 3.5L EcoBoost SCrew
JackandJanet is offline   Reply With Quote
Old 04-22-2017, 11:29 AM   #4
Senior Member
 
Join Date: Nov 2011
Location: reno, nv
Posts: 406
Default

The hand pump came out many year after your trlr was made.
I also have a 1985.
The manual way to lower
You will need more than one farm jack lift. Bottle jack would work also
And some lumber.
Lift front to release safety. Then inch your way down until you can depress down switch.
The hydraulic pump only works on the way up.
It's always something.

I must add that I have never had to do this, thank goodness.
__________________
2002 ford f350, 7.3 diesel
1985 hi-lo funchaser
kb0nai
kd7ctk
renoites is offline   Reply With Quote
Old 04-22-2017, 11:43 AM   #5
Site Team
 
Treeclimber's Avatar
 
Join Date: Feb 2015
Location: SWFL Bonita Springs/Andrews, NC
Posts: 1,264
Default

If you do it with man power, they would not be able to control the tops decent! Might get ugly. As stated two farm jacks are needed along with lumber. You must control the decent! If your cylinder is blownagain you can't control the decent once off the bar. Wish I were there to assist.
Tree
__________________
Treeclimber
2703 Tow Lite
2002 Escalade
Bonita Springs, Fl. &
Andrews, NC
Treeclimber is offline   Reply With Quote
Old 04-22-2017, 12:53 PM   #6
Site Team
 
JackandJanet's Avatar
 
Join Date: Jul 2010
Location: Pine, AZ
Posts: 4,525
Default

Quote:
Originally Posted by Treeclimber View Post
If you do it with man power, they would not be able to control the tops decent! Might get ugly. As stated two farm jacks are needed along with lumber. You must control the decent! If your cylinder is blownagain you can't control the decent once off the bar. Wish I were there to assist.
Tree
Good catch, Tree - I hadn't thought about a blown cylinder allowing the top to free fall.

Sounds like several pieces of lumber are needed as well as a saw to reduce their lengths during the descent. Not fun!

However, using the tongue jack to tilt the trailer forward and backwards, you could get by without using farm jacks to both raise and lower the top. Again, it takes 2x4s that reach from the top to the ground as well as ones that reach from the top to the outriggers.

Any way you do it, it's going to be a tedious process.

- Jack
JackandJanet is offline   Reply With Quote
Old 04-23-2017, 08:34 AM   #7
Junior Member
 
Join Date: Feb 2017
Location: ohio
Posts: 2
Default

Thanks to everyone for your assistance. I got lucky, I was able to put more atf in the reservoir to get it to lift off safeties. It spewed a lot of atf but was able to get it home. I am so lucky that this site is here to get help with everything on the trailers. Thanks again to everyone.
jackarussel is offline   Reply With Quote
Old 04-23-2017, 09:35 PM   #8
Site Team
 
Treeclimber's Avatar
 
Join Date: Feb 2015
Location: SWFL Bonita Springs/Andrews, NC
Posts: 1,264
Default

Happy to hear all ended well.
__________________
Treeclimber
2703 Tow Lite
2002 Escalade
Bonita Springs, Fl. &
Andrews, NC
Treeclimber is offline   Reply With Quote
Old 04-23-2017, 11:06 PM   #9
Site Team
 
JackandJanet's Avatar
 
Join Date: Jul 2010
Location: Pine, AZ
Posts: 4,525
Default

Good to know that adding fluid made things work well enough to raise it and then get it down. I'll keep that cure in mind. Glad you didn't have to resort to any of our "helpful" ideas! *grin*

- Jack
JackandJanet is offline   Reply With Quote
Old 04-24-2017, 11:33 AM   #10
Member
 
city Bear's Avatar
 
Join Date: Mar 2017
Location: Kansas
Posts: 17
Default

The adding of ATF to the reservoir was a good idea and a good to know if there is problem with the lift system. Thank you.
__________________

city Bear is offline   Reply With Quote
Reply

Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


» Featured Campgrounds

Reviews provided by

Powered by vBadvanced CMPS v3.2.3
Disclaimer:

This website is not affiliated with or endorsed by Hi-Lo Trailers Worldwide or any of its affiliates. This is an independent, unofficial site.


All times are GMT -5. The time now is 04:46 PM.


Powered by vBulletin® Version 3.8.8 Beta 4
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
HiLoTrailerForum.com Copyright 2010
×