|
06-20-2010, 06:07 PM
|
#1
|
Member
Join Date: Jun 2010
Location: Northern Florida
Posts: 70
|
78 hi lo...help !
anyone out there grease the side rails on their hi lo ? the rails the trailer rides up & down on, should i use spray on lithium grease or the hydrolic grease i used on cables and guide rod???
__________________
|
|
|
06-20-2010, 09:22 PM
|
#2
|
Moderator
Join Date: Apr 2010
Location: Napa,CA
Posts: 933
|
FHILO,
The water system is pressurized when you hook-up to city water with a water hose. Make sure you use a pressure regulator to prevent a waterline burst inside the trailer. Is this portion of the water system working for you?
The freshwater system (tank and pump) is used when not hooked up to water with a hose. Fill fresh water tank, (after you get the system working, you need to sanitize it with bleach and flush it out with fresh water including the water heater-there is drain on the lower front of the waterheater).Turn on the 3-way switch to 12v or plug the trailer into 110v. There is a switch for the pump (Mine is located above the refrigerator next to the countertop). The pump automaticitly pressurize the water system using water from the freshwater tank. If the pump doesn't turn on, check if you have 12v to the pump. Check the fuse (my fuse box is under the couch).
The furnace also needs 12v from the battery or 12v thru the converter when pluged into 110v. Check the fuse and check voltage at the furnace. Turn propane (I always light my stove to make sure there is no air in the line). Turn on thermostat, the fan will come on next , the spark ignitor will start and the flame sensor will turn on gas valve.
The tail lights being dim, I sounds like the light bulb sockets aren't clean or you don't have a good ground.
I found with alot of electrical problems I had was caused by not having a good ground.
I hope this helps
On this forum you should be able to get a owner's manual, if not for your year, maybe something close.
__________________
__________________
Les & Patricia
2006 22ft towlite (replaces 97 21TL)
2006 Toyota tacoma pre-runner 4.0 L V-6 quad cab
w/ 98 chevy Powervision towing mirrors
2017 Chevy Silverado 1500 5.3 v8 (replaces Toyota)
2 Hobie mirage pedal drive kayaks
|
|
|
06-21-2010, 12:20 PM
|
#3
|
Member
Join Date: Jun 2010
Posts: 5
|
I also have a 1978 HiLo. I do have a manual that the previous owner ordered from the factory. It's only a photocopy, but in it has a chart with model numbers for that year with other info. I don't have a scanner, but I did recreate that chart on a Microsoft Word Doc for you. It wouldn't allow me to post it on here because it said it was too big. I haven't been able to figure out what my model is either, only that it must be one on the list.
Anyway, if you (or anyone else) is interested in this chart, send me a private message with your email addy. Maybe eventually, I can post the entire manual, but the rest of it looks very similar to the much newer model manual posted on this site.
Nancy
|
|
|
06-23-2010, 01:00 AM
|
#4
|
Moderator
Join Date: Apr 2010
Location: Napa,CA
Posts: 933
|
FHILO,
We were having trouble with dim tail lights also, so we upgraded the light bulb to a LED light. See the following link to another section in this forum.
We love the results. Made a huge difference.
http://www.hilotrailerforum.com/f19/...s-239/#post623
__________________
Les & Patricia
2006 22ft towlite (replaces 97 21TL)
2006 Toyota tacoma pre-runner 4.0 L V-6 quad cab
w/ 98 chevy Powervision towing mirrors
2017 Chevy Silverado 1500 5.3 v8 (replaces Toyota)
2 Hobie mirage pedal drive kayaks
|
|
|
06-23-2010, 11:59 AM
|
#5
|
Junior Member
Join Date: Jun 2010
Posts: 1
|
Nancy,
I have a 1979 HiLo funtime camper with no papers or manuals. Any info you would like to share would be wonderful for me. If you can email this info to me it would be great.
Thanks,
Mike
|
|
|
06-24-2010, 09:10 AM
|
#6
|
Member
Join Date: Jun 2010
Posts: 5
|
I'm happy to share that Mike. I need your email address though. You can send it through Private Message, if you want to. I tried to upload it in a reply and through PM to you, but the site says it's too big for some reason.
Nancy
|
|
|
06-28-2010, 08:41 PM
|
#7
|
Member
Join Date: Jun 2010
Location: Northern Florida
Posts: 70
|
hi lo manuel etc.
|
|
|
07-08-2010, 06:29 PM
|
#8
|
Member
Join Date: Mar 2010
Location: Jamestown, NY
Posts: 43
|
Regarding lubricating the slides: I use silicon spray. Spray it on a cloth and rub the slides, then spray up in the guides. Works for me!
|
|
|
07-11-2010, 10:31 AM
|
#9
|
Member
Join Date: Mar 2010
Location: Jamestown, NY
Posts: 43
|
I Guess you aren't certified as a camper until you learn to fix STUFF. Good luck with your future fixes.
|
|
|
05-09-2011, 02:11 PM
|
#10
|
Member
Join Date: Nov 2010
Location: Port Clinton, Ohio
Posts: 24
|
Lubricating the slides
I haven't seen very much information in the forum regarding this subject, so I thought I would let you know what I was told to do.
After we bought our unit, I visited JR Enterprises to learn what I could about maintaining our HI-LO. We don't live to far from them, so it wasn't difficult to do and having worked as a pleasure boat service manager for almost 30 years, I had some knowledge of what questions to ask. I was lucky enough to meet and talk to Greg Stanley, now deceased, who was able to give me many good suggestions on what to look for and how to maintain our unit.
As for the slides, he suggested using paraffin wax on the guides 3 or 4 times per season. This is the wax used for canning. It is inexpensive and easy to apply with no over spray to mess with. I have used it now for 4 years with no problems. Hope this helps you out.
__________________
2006 280C HI-LO
2017 F 250 XLT Diesel Super Crew
Equalizer Hitch
|
|
|
05-20-2011, 07:29 AM
|
#11
|
Senior Member
Join Date: Apr 2011
Location: The WILD West!
Posts: 115
|
Quote:
Originally Posted by rogerssj
I haven't seen very much information in the forum regarding this subject, so I thought I would let you know what I was told to do.
After we bought our unit, I visited JR Enterprises to learn what I could about maintaining our HI-LO. We don't live to far from them, so it wasn't difficult to do and having worked as a pleasure boat service manager for almost 30 years, I had some knowledge of what questions to ask. I was lucky enough to meet and talk to Greg Stanley, now deceased, who was able to give me many good suggestions on what to look for and how to maintain our unit.
As for the slides, he suggested using paraffin wax on the guides 3 or 4 times per season. This is the wax used for canning. It is inexpensive and easy to apply with no over spray to mess with. I have used it now for 4 years with no problems. Hope this helps you out.
|
Where did you find this wax? Just from the canning section of the grocery store?
We probably have some stashed away here at the house somewhere...
|
|
|
05-20-2011, 07:51 AM
|
#12
|
Moderator
Join Date: Feb 2010
Location: NW PA
Posts: 3,386
|
You answered your own question, the canning section of the store. Or, steal it from a jar of homemade jelly.
__________________
__________________
My Great Wife Joyce
2018 Jayco Jay Flight 21QB
Formerly owned 1705T and 2310H
2012 F150 4X4 SuperCrew EcoBoost w/Leer Cap
Reese WD Strait-Line Hitch
Amateur Radio K3EXU
|
|
|
|
Thread Tools |
Search this Thread |
|
|
Display Modes |
Linear Mode
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|